Section Repair
Dry roofs with a few failed seams get commercial roof repair at those spots, with curbs reflashed where they leak.
Central City Commercial Roofing Contractor
Raise Short Curbs and Replace Soft Deck Before the New Membrane Goes Down
As a Central City commercial roofing contractor, we repair and replace roofs on Muhlenberg County shops, offices, and warehouses, deck and curbs included.
- Deck checked from inside
- Curb heights measured
- County inspector path noted
What a Central City Commercial Roofing Contractor Checks First
A Central City commercial roofing contractor has to know what sits under the old membrane before pricing a new one. In Central City, reroof questions go first to the Muhlenberg County local building inspector, and the items that draw review are the same ones that change the roof plan.
- Deck sections that need replacing once the old membrane is torn off
- Curbs too short to flash after new insulation goes down
- New drains or relocated downspouts
- Retrofit framing for a metal roof over a flat one
Central City City Hall is the second call, for any rules inside city limits.
Commercial Roofing Problems on Central City Buildings
These are the conditions that turn a simple reroof into deck and curb work once the old roof comes off.
Spongy spots near old leak areas
Likely CauseYears of wet insulation rusted the steel deck flutes or rotted wood decking under the stain.
What We DoSoft deck is cut out and replaced during tear-off, before any insulation goes back down.
Unit curbs barely above the membrane
Likely CauseEach past recover raised the roof surface while the curbs stayed at their original height.
What We DoCurbs are raised so flashing turns up to full height, with unit disconnects handled by your mechanical contractor.
Downspouts spilling onto walks
Likely CauseGutters and outlets were placed for an older roof layout and no longer match the drainage.
What We DoNew drains or relocated downspouts are drawn into the plan and raised with the county inspector.
Stains returning after patches
Likely CauseWater was entering uphill of the patched spot and running along the deck to the same bay.
What We DoCore cuts upslope of the stain find where the boards are wet and mark the true section to replace.
Benefits of Fixing the Deck During a Reroof
Deck and curb work costs least when the old roof is already off.
Soft deck under a new membrane
New insulation laid over weak decking flexes underfoot and cracks the cover board above it.
What The Reroof DoesReplaced deck sections give the new assembly a firm, flat base from the start.
Flashing too short at units
Membrane that can only turn up a few inches at a curb leaks as soon as water ponds beside it.
What The Reroof DoesRaised curbs leave room for flashing at full height on every unit.
Thin insulation from an older roof
Older assemblies often carry far less insulation than current energy rules call for.
What The Reroof DoesInsulation is brought up to code levels, and Kenergy can be asked whether a program counts it.
Drains left at the old height
A thicker new roof leaves old drain bowls sitting low, so water collects in a ring around them.
What The Reroof DoesDrains are reset or extended to meet the new surface.
Commercial Roofing Options for Central City Owners
The roof walk usually narrows a Central City building to one of these three.
Tear-Off And New Membrane
Wet roofs come off to the deck for repairs, then get a TPO or EPDM membrane over new insulation and cover board.
Metal Retrofit
Flat roofs that keep ponding can take retrofit framing and metal panels, reviewed by the county inspector.
Ceiling Stains Spreading Across Several Bays?
Several stained bays usually means wet insulation over a wide area. Call and tell us how many, and the walk will start with core cuts there.
Roof Replacement Order of Work in Central City
Deck and curb repairs fit into the replacement at set points.
Inspect Your Roof
We walk the roof, look at the deck underside from inside, and take core cuts near every old leak area to size the wet sections.
Call The County Inspector
Deck replacement, raised curbs, drain changes, and any retrofit framing go to the Muhlenberg County local building inspector before materials are ordered.
Remove And Repair The Deck
Each section comes off to the deck, and rusted or rotted deck is replaced the moment it is exposed.
Raise Curbs And Reset Drains
Curbs get taller framing and drains get new rings at the new roof height before insulation goes down.
Build And Seal The Roof
Insulation, cover board, and membrane go on, curbs are flashed, and the section is tied in before the crew leaves.
Nearby Towns We Work In Beyond Central City
Central City is one of several towns where we take commercial roofing work. If your building is elsewhere, call us or send us a message.
- Owensboro Home base under OMPC permits
- Beaver Dam Ballast swaps and metal framing
- Hartford Parapets, coping, and scuppers
- Hawesville Rooftop unit wiring and conduit
- Livermore Recover checks and purlin work
- Calhoun Adhesive work timed to the weather
- Lewisport
- Philpot
- Whitesville
- Maceo
- Utica
Central City Reroof Questions
Who reviews a commercial reroof in Central City?
The Muhlenberg County local building inspector, listed on the county’s sheet with the Kentucky Department of Housing, Buildings and Construction, is the first call. OMPC has no role outside Daviess County.
Central City City Hall is the second call for local rules. Muhlenberg County is Kenergy territory, so insulation program questions go to the co-op.
How is deck replacement under a torn-off membrane priced?
By the area actually found damaged once the roof is open. Core cuts before the job estimate the wet zones, and the estimate lists a unit price for deck replacement so the final amount follows the real square footage instead of a guess.
Why do rooftop unit curbs need raising during a reroof?
New insulation raises the roof surface, which shortens the height left for flashing at each curb. Raising the curb restores that height so the membrane can turn up and seal properly. Your mechanical contractor disconnects and reconnects the unit while the curb is built up.
Can a Central City roof be replaced while the business stays open?
In most cases, yes. Sections are opened and closed in the same shift, debris chutes and dumpsters are placed away from customer entrances, and any unit over an occupied room is shut down on a schedule set with you ahead of time.
What should a Central City owner gather before the roof walk?
Any roof drawings, past repair invoices, a list of bays where stains appear, and the age of each roof section. Note which rooftop units are due for replacement soon, since matching that timing with the reroof saves cutting curbs twice.
Call a Central City Commercial Roofing Contractor
Tell us the building’s street and where stains show inside. We will walk the roof, size the deck and curb work, and give you a free estimate.